Close

Onan RV BGE / BGEL Emerald I - repair parts

Below are two charts of common repair parts for Onan BGE / BGEL Emerald I series.

Notice: The first chart is for Spec range A-E and the second chart is for Spec range F-P.
The spec letter of your generator is the last letter in the full model. (example 4.0BGE-1R/26100E.... "E" would be the spec)

For other Onan RV generator parts not listed on our website, please contact your local Onan distributor.

Some parts specified below are aftermarket replacements that are equal or better to the original parts and usually have a superior warranty.

NOTICE: Although every effort is made to supply the correct information, we are not responsible for typographical errors / inaccuracies on this website. Sometimes parts are obsoleted or superseded and it is very difficult to keep all of these changes updated on a daily basis. If you order the wrong part(s) online, we cannot be responsible.

CHART # 1 FOR Models BGE / BGEL Spec A-E:

 

Models BGE (Emerald I) Spec A-E and BGEL Spec B-D

Control Board
Regulator Transformer

Carburetor (Gas)

Carb Repair Kit (Gas)-This is for a NIKKI

Carb Repair Kit (Gas)-This is for a FACET

Air Filter

Oil Filter

Fuel Filter-Spec (A-E)

After Market Fuel Filter-Spec (A-E)

Fuel Filter-Spec (F)

Fuel Filter-Model (BGEL-Propane)

Start Solenoid

Starter Motor

Ignition Coil

Brushes

Points
Tune-up Kit (Points & Condensor)

Start/Stop Switch

Fuel Pump-Rectangular

Fuel Pump-Cylindrical

Oil Pressure Switch

Spark Plug
Spark Plug Cables:

You can buy qty (1) 9 inch:

Click Here

OR a set of (2) 26" cables - 167161601-A (Aftermarket) (you can cut to desired length):

Click Here
Generator Stator
Generator Rotor this is for Spec A, NLA. For Spec B and later

Service Manual BGE (Spec A-E), BGEL (Spec B-D)

Chart # 2 for Models BGE/ BGEL Spec F-P:

Models BGE Spec F-P and BGEL Spec E

Control Boards:
For Spec E thru G, look at number on bottom of your board for these possibilities: 300-3056, 300-3687, 300-3763, 300-3763-01, 02, 03, 04, 300-5268-01

For H-M, use 300-3763, 300-3763-01, 02, 03, 04, 300-5268-01

For Spec N-P, use 300-4901, 300-5337-01, 300-5337-02


Voltage Regulator

Carburetor (Gas)-Spec (F-J)

Carburetor (Gas)-Spec (K & After)

Carb Repair Kit (Gas)

Air Filter

Oil Filter

Fuel Filter-Spec (F-G)

Fuel Filter-Spec (J & After)

Fuel Filter-Spec (H)

Start Solenoid

Starter Motor

Ignition Coil-Spec (E-F)

Ignition Coil-Spec (G Through S/N G923938483 During Spec J)

Ignition Coil-Begin S/N G923938484 During Spec J

Ignition Control 15" lead-ONLY Spec G and after

Ignition Rotor

Brushes

Tune-up Kit (Points & Condensor)

Start/Stop Switch-Local/On Generator

Start/Stop Switch-Remote

Fuel Pump-Rectangular Style-Spec (F-G)

Fuel Pump-Spec (H)

Fuel Pump-Spec (J and beyond)

Oil Pressure Switch

Spark Plug
Spark Plug Cables:

You can buy qty (1) 9 inch:

Click Here

OR a set of (2) 26" cables - 167161601-A (Aftermarket) (you can cut to desired length):

Click Here
Generator Stator
Generator Rotor

Service Manual BGE (Spec F-K), BGEL (Spec E-K)

NOTICE: Although every effort is made to supply the correct information, we are not responsible for typographical errors / inaccuracies on this website. Sometimes parts are obsoleted or superseded and it is very difficult to keep all of these changes updated on a daily basis. If you order the wrong part(s) online, we cannot be responsible.